Methanol Fuel-Cell Battery For Your Laptop?

Nick writes: "I ran across this accidentally when I was researching fuel cell cars. They have come out with a little methanol fuel-cell battery they hope will be more powerful than lithium ion batteries, at competitive prices too! (well, in five years maybe) Also check out howstuffworks for a great article on fuel cells in general." Beating Li-Ion batteries by a factor of ten is a very worthy goal.

Comments

Carts Re:it remains to be seen...

[StefanJ]

Prototypes were depicted as using sealed, pen-sized cartridges. No filling necessary. I imagine that screwing them into the fuel cell would break a seal allowing a controlled stream of methanol to be fed into the reformer.

I suppose that the manufacturer would initially charge a lot for these, but refill kits would appear shortly.

Stefan

Did some due diligence on this....

[nellardo]

I did some due diligence on this kind of technology for a VC firm out of the Bahamas. They were considering investing in a spin-out from the Jet Propulsion Lab. If you check you'll see a dorky researcher holding a prototype and if you go here you'll see a newer stack. You can also read a bit about it.

The one I saw, intended for eventual use in cell phones, was basically what looked like a sandwich of plexiglass and some spongy material. Two wires ran off from the sponge to connect to the contacts for a small fan. You'd take a bottle of methanol, squirt it on the sponge, and the fan would start to spin, slowly at first, and building up in speed as the cell heated up to optimum temperature (which I think was around 50-60 degrees celsius).

Cell phones make a good first application for this kind of technology (as opposed to cars) because the price/performance ratio is high (cell phones are expensive for the amount of power they use) and the performance/weight is relatively low (you don't need a really big stack to drive cell phone). If the fuel-cell cell phone (or even just a widget to replace the battery) costs ten times as much, but lasts ten times as long, is fully "rechargeable" with a one-minute application of methanol (which could come in sealed, disposable plastic tubes, or you could fill it the same way you fill a butane lighter), and has no "memory" problems, then you've got a real winner. People will pay $1000 for a cell phone (they did when the StarTAC first came out).

A car that costs ten times as much doesn't work, because that puts even a cheapie car into six figures. You have to get the price-performance ratio of fuel cells way way down before they become useful for cars. However, for cars, methanol distribution may not be a big problem - some researchers are working on gasoline-driven fuel cells. Not as clean as methanol (which exhausts CO_2 and H_2O), but cleaner than combustion, and the distribution infrastructure is already in place. There's still a price/performance problem, because gasoline-powered fuel cells effectively have a full chemistry lab built in, with three or four stages to go through before the actual power production. They also operate at much higher temperatures.

Direct Methanol Fuel Cells are nifty because they're solid-state. A catalyst (platinum, I think) drives the methanol/oxygen -> power/water/carbon dioxide reaction. They do have problems with supporting rapid changes in electrical draw, however. Typically this is handled by putting them in series with a capacitor. The capacitor can soak up rapid increases in demand, while the cell itself adjusts.