Hack Your Ignition (Before Someone Else Does)

guanxi writes: "IEEE Spectrum has an interesting article about hacking and specifically, the "hacker's nirvana on wheels", all the way from hot-rodding to reprogramming your digital ignition. Of course, I neither endorse nor recommend any of the procedures mentioned, any of which may be inherently dangerous to your life and your warranty. "

Comments

car mods

[flynt]

here is a sweet page about modding cars. It can turn you into a ricer real quick. Car mods are pretty popular these days in my town, from big fins to stickers, to large exhaust pipes, there's just no end to the mods.

Actually, this car hacking stuff is old hat.

[BeerSlurpy]

Two points: ONE: most cars do NOT benefit from performance computers. TWO: most performance computers are added on to cars that are normally naturally aspirated and converted to turbo form. (a lot of cars that dont have turbos from the factory judge the amount of air with a vaccuum sensor instead of a mass air sensor) Often the relevant sensors dont even exist for the stock computer to talk to.

To make an example, the average honda civic computer settings are pretty much already maxxed out in stock form. You add an intake and an exhaust and youre still in the range that the stock computer can adjust for. You can actually add about half an atmosphere of boost (from turbo or supercharger) and still not need a custom computer. This applies to a most other non-turbo cars as well. Factory turbo cars have even higher limits.

Remember, modern cars have to be able to operate at 10,000 feet above and below sea level in a wide range of temperatures. Most cars have injectors that can take about 150% to 200% of stock duty before they begin to max out. Up to this point the car will still not even pollute!

Basically the only 2 ways to outpace the stock computer is to

1)bring in too little air at idle or have massively oversized injectors (the computer can't control the injectors to produce less than a certain minimum period of being open) which will cause "lopey idle" or stalling and rich emmissions.

2)bring in so much air at high rpm that the stock injectors can't let in enough fuel. Basically you will start to run "lean" (not enough fuel) which will produce very high temperatures and detonation (and kill your engine).

You basically only need a special computer if you are running massive cams (alternatively you could just raise the idle, which most people do) or if youre running such massive amounts of boost that the only solution is to run massive injectors (here again, you can actually just raise the idle). Now consider this: when youre making over double the stock hp, there is no way a factory computer is going to be able to cope anyway- I dont see the point of making them more hackable. On top of which, the only reason to use an expensive computer is to make the car more emissions friendly. And guess what mods are pretty much illegal under CARB rules? You guessed it! Programmable ECUs!!! The high-boost 323 and miata guys routinely run hacked ECUs with 12-15psi of boost, then turn down the boost and swap injectors for smog every two years. Its pretty sad that you have to break the law to pollute less.