New Process For Nanoscale Filtration Holds Promise of Cheap, Clean Water

New submitter Spinnakker writes "Lockheed Martin, traditionally known for its development of military systems and aircraft, has developed a process for perforating graphene (carbon sheets only one atom thick) that could potentially reduce the energy required for desalination by two orders of magnitude. The process tailors the hole size to the molecules being separated. In the case of desalination, one would create holes in the graphene large enough to allow water to pass but small enough to block the salt molecules. The advantage to using graphene comes from how extremely thin the material is compared to traditional filters. The thinner the filter, the less energy is required to facilitate reverse osmosis."

Comments

Holy moly

[i kan reed]

I remember when this theoretical technology was proposed about a year ago, and figured it would be a decade before they could actually do it.
Cheap desalinization and filtration would mean an end to one of the biggest world health problems(safe drinking water), and could improve world-wide standards of living dramatically.

Re:Holy moly

[Ol Biscuitbarrel]

i don't think its feasible collecting rain water straight from the sky though

Sure it is, people have been doing it for millenia: Brief Outline of the History of Rainwater Catchment Technologies

Archaeologists found a sophisticatedrainwatercollection and storage system on the island of Crete while working on the reconstruction of the Palace of Knossos (1700 B.C.). However, with the development of building construction based on new materials such as lime and burnt clay bricks, new construction techniques like arches and domes developed. The ancient Romans became masters inrainwaterharvesting and the construction ofreservoirs. It was this new technique of building closed cisterns, and at the same time the urbanization within the Roman Empire around the Mediterranean, which resulted in the development of arainwatercatchment culture at all those places where water resources were limited. This is why oldrainwatercisterns are to be found on the islands of Capri and Malta and at places of historical interest in Spain and Turkey, in the Lebanon and on the island of Sicily.

Plenty of research is being conducted on modern approaches to rainwater harvesting. In the developed world these often come into conflict with environmental regulations regarding water quality, and in general there's a surfeit of water from other sources that is ran through central filtration facilities so no great press is on to tap rainwater as a major source. It's something popular with people who are interested in green tech and the like.

Re:Holy moly

[interkin3tic]

Yes, but we still need to figure out the other half of the problem of desalination, which is what to do with the high-salt brine. If you get 50% efficiency, as much water as you get out, you'll get out wastewater with 200% salt in it. In large volumes, you obviously can't store it or evaporate it off fast enough. Dumping it into the ocean will kill anything near the exhaust. And then there's still the problem of piping the water to cities.

It makes more sense to use this to filter out municipal waste water and re-use it for drinking water. It's right there where you need it, it's got less junk to get out than seawater, and there is less byproduct. The only problem with that is people don't like the idea of drinking their own sewage, even if it has been filtered well.

Not to be a wet graphene blanket: this is a very good thing, you're absolutely right that it will improve the standard of living worldwide if it pans out, and we do need better filtration technology. Just that we shouldn't forget the ecological concerns.

Re:Holy moly

[the eric conspiracy]

Holes in membranes are a fact of life. The reason they aren't crucial for desalinization is that you don't need ion free water for it to be potable. In fact it's common to add ions back in after desalination because pure water is much more corrosive than typical drinking water.

Disease organisms are a different issue altogether.

Post treatment growth of micro-organisms is a fact of life. Some sort of treatment with a residual action is absolutely needed. Usually this is chlorine or chlorine compounds. Maybe in a home system you can get away without it but certainly not in a municipal water system.

This isn't new knowledge folks. People have been doing this for decades.

http://www.fwrj.com/techarticles/1109%20fwrj_tech1.pdf

Re:Holy moly

[Anonymous Coward]

what does that leave, purification of certain compounds which happen to be smaller than H2O. ... This leaves H He Li Be Bo C N O Fl Ne

He & Ne aren't a problem - 1) they're a gas, and He, at least, is sparingly soluble in water, so it'll all bubble off. 2) They're as inert as they get, so wouldn't make much of a difference even if they were in the water.

C N O - Aren't found as mono-atomic atoms. Will always be in larger molecules, which for the most part are larger than water.

H Li Be B F - Found as monoatomic species, but only as ions. With ions you always get a shell of hydration around them, and it's a significant amount of work to strip that away. Effectively, you don't have a Li+ on its own, you have a Li+(H2O)x complex, which by necessity will be bigger than a single water molecule

The only thing you'd be worried about are small, neutral molecules. Something like methane might be a problem, but if you have methane in your source water, you probably know it, and will have some other pre-treatment to deal with it specially.

Re:expensive filter will get gummed up in no time

[fustakrakich]

...how many holes?

Enough to fill the Albert Hall

Current technology is already efficient

[drmaxx]

Considering that the theoretical minimal energy requirement for seawater desalination is approx. 0.75 kWh/m3 and current RO technology can be as low as 1.5 to 2 kWh/m3 (+ an other 2 kWh/m3 to pretreat the seawater) then I am really wondering how they will gain two orders of magnitude less energy? Can anybody enlighten us about that?

Re:Waterworld

[onkelonkel]

You can pee into a glass mug and get Coors Light.