Some Recyclers Give Up On Recycling Old Monitors And TVs (vice.com)

An anonymous reader writes: "In many cases, your old TV isn't recycled at all and is instead abandoned in a warehouse somewhere, left for society to deal with sometime in the future," reports Motherboard, describing the problem of old cathode-ray televisions and computer monitors with "a net negative recycling value" (since their component parts don't cover the cost of dismantling them). An estimated 705 million CRT TVs were sold in the U.S. since 1980, and many now sit in television graveyards, "an environmental and economic disaster with no clear solution." As much as 100,000 tons of potentially hazardous waste are stockpiled in two Ohio warehouses of the now-insolvent recycler Closed Loop, plus "at least 25,000 tons of glass and unprocessed CRTs in Arizona...much of it is sitting in a mountainous pile outside one of the warehouses."
One EPA report found 23,000 tons of lead-containing CRT glass abandoned in four different states just in 2013.

Comments

Bad Waste Policy

[retroworks]

I'm a professional CRT recycler with experience with the companies in the article. The leaded silicate in CRT glass can actually be valuable as a fluxing agent. It's basically the same as anglesite, the leaded quartz that's mined worldwide. But because of e-waste alarmism (e.g. original article said they were full of "toxic gases", still says the CRTs "explode"), the primary copper and lead smelting industries stopped accepting the material. I personally managed several hundred tons of cullet from one on the companies in the article, but the smelter didn't like the regulators and environmentalists poking around, or the red tape. So they went back to mining lead and silica from the ground. Here's an article I wrote about the "no good deed goes unpunished" aspects of CRT glass recycling. resource-recycling.com/pdfs/Ingenthron0316e.pdf Previously I wrote one - also published in Motherboard - about how Asian refurbishers stopped buying CRTs from America for the same reason (they were being cast as "primitive wire burners). motherboard.vice.com/2011/3/26/e-waste-recycling-exports-are-good

A good rule of thumb is that the worst forms of recycling are better for the environment than the best forms of hard rock metal mining. But "waste" policy says the opposite, waste is a "liability" for the consuming industry, mined material is subsidized.