First Exotic Space Thruster Test Ends in Explosion

KentuckyFC writes "A NASA-funded test of an entirely new way to control orbiting satellites has ended with the prototype arcing dangerously and parts of the machine exploding. The new propulsion system is based on the Lorentz force: that a charged particle moving through a magnetic field experiences a force perpendicular to both its velocity and the field. So the plan is to ensure that a satellite passing though the Earth's magnetic field is electrically charged so as to generate a force that can be used to steer the spacecraft. The advantage of the idea is that it requires no propellant, which is a big deal since most satellites' lifespans are limited by the amount of fuel they can carry. But the first ground-based tests haven't gone entirely to plan."

Comments

Jazzing up the story a bit

[Goaway]

As much as we all like a good explosion, that summary seems highly misleading. From the abstract:

Microscopic arcing was observed at voltages as low as -300 V. This arcing caused solder to explode off of the object. Insulating the object allowed the charge to remain on the object longer, while in the plasma, and also eliminated the arcing. However, this insulation does not allow a net charge to reside on the surface of the spacecraft. "Caused solder to explode off the object" hardly sounds like much of an explosion.

Another variant also had problems.

[Ungrounded Lightning]

Another variant of this is to have two weights connected by a wire tether and tide-locked to the primary, so the wire is oriented at roughly right angles to the orbit. Then you put a current in the wire by ejecting electrons on one end and collecting them at the other - making it into a motor that can accelerate or decelerate along the orbit. No reaction mass, run it off the solar collectors, etc. This also ran into issues with arcing.

They tried an experiment on this with the shuttle and a tether to a satellite they were launching, and found a problem: The motion along the orbit also causes it to act like a generator, powered by the orbital momentum. (This was known - and also has possible uses.) This produces a voltage gradient along the wire tether. So the tether has to be insulated to prevent arcing to the very low-pressure plasma that constitutes the high atmosphere and solar wind.

What they discovered was that minute flaws in the insulation caused localized arcs to the surrounding plasma. These were powered by the orbital motion relative to the earth's field and were very intense. They quickly melted through the thin tether.

So such a motor is not an impossibility. But it will require some heavy engineering work to get around this problem.

(It also says that large-scale tethered orbital structures have an additional problem to be solved: Keeping the tethers intact despite kilovolts of induced voltage along the tether and the resulting arcing.)

It's easy to think of space as filled with a hard vacuum. Unfortunately it's actually filled with very low pressure conductive plasma and near the Earth that's dense enough to be a major engineering issue.

Re:It's Rocket Science

[CCFreak2K]

From Wikipedia:

As with many rockets, the initial flights of each new Ariane model have seen failures. However, overall, the Ariane 4 and 5 are the most reliable commercial rockets ever launched. As of January 2006, 169 Ariane flights have boosted 290 satellites, successfully placing 271 of them on orbit (223 main passengers and 48 auxiliary passengers) for a total mass of 575 000 kg successfully delivered on orbit. This success rate also makes Arianespace the foremost commercial launcher; in some years, more than two thirds of all commercial satellites have been launched with the company's vehicles.