Virginia Approves First Offshore Wind-Energy Turbine For US Waters

New submitter mike2400 writes "According to the Virginian Pilot, the U.S. is closer to having offshore wind turbines. Gamesa, a Spanish manufacturer, has partnered with Newport News Energy, a subsidiary of Newport News Ship Building and Huntington Ingles Industries, to build the first offshore wind turbine in the U.S. It will be located in the Chesapeake Bay off the shore of Cape Charles, VA, which is located on Virginia's Eastern Shore. The prototype 5 MW unit (the article said 5 kW — that's a typo) should be up and running by next year."

Comments

How much for how much?

[Gothmolly]

How much is it costing to get that 5MW of power?

Re:How much for how much?

[MDillenbeck]

Dunno - how about asking how much the total life cycle cost of 5MW of wind power vs total life cycle cost of 5MW of coal power? In these costs, include all subsidies or their fractional equivalents. Don't forget the cost of transporting feedstock, the cost of mining the materials for construction of the initial plant, the subsidies included in the fuel to transport the feedstock, and so forth. Shall we get into potential health costs - both to those living near the power generators and those who mine the materials and feedstock? Often I find people exclude a lot from the costs of one source of power (coal) to skew the results. Now, I'm not saying wind power is cheap - but I am saying it is like a comparing an MMO to a stand-alone game... one you have to pay over the lifetime of use, the other you pay mainly up-front costs.

Re:How much for how much?

[WindBourne]

You are also confusing the fact that off-shore winds blow pretty steady compared to on-land. IIRC, it will produce more more than 33% (which is the norm for most wind).

Re:How much for how much?

[Luckyo]

Off-shore wind farms have a problem of wind blowing too fast, forcing shut down of the farm. This is something that danish and german folks discovered early in their attempts to get wind farms to produce meaningful amounts of power.

It's even worse in oceans then inland seas.

Re:How much for how much?

[blindseer]

If we're going to add up these costs for coal then we need consider the incidental costs for wind as well. First thing that comes to mind is the 5MW natural gas turbines needed for when the wind does not blow.

Re:How much for how much?

[Anonymous Coward]

That was a problem with older designed. Modern designs use a regenerative braking technique which allows the turbine to not only generate more power throughout its operating range, it also allows the turbine to function in much higher wind environments. Older design's vulnerability was an over-rev, therefore requiring them to shutdown to prevent this during high winds. Modern designs simply use more "braking", which in turn generates more power. Thusly, the limiting factor becomes structural rather than rev.

Just because people with older designed had problems doesn't mean people using moderns designs, specifically designed to work around such limitations, will encounter the same issue. Of course, I have no idea if they are employing modern turbine techniques or not. Just the same, technically, it need not be an issue.

Re:How much for how much?

[cbope]

You know... it's amazing that every time alternative energy opportunities come up in the US, there are always people standing in line with 1000 reasons why it CAN'T be done.

With this kind of attitude you will NEVER get weaned off fossil fuels and digging big holes in the ground. You must be able to accept compromises, there is no 100% perfect solution to the world's energy needs. A balanced and layered approach is what will do the job, yet these are all blocked for insane reasons.

Grow a pair, and build out the alternative energy infrastructure you desperately need. You can no longer rely on fossil fuels as your main energy source. You will need nuclear, wind, solar and water power generation to provide your energy. Yes, taken individually, each have their drawbacks. That is why you need a layered approach. Combined, there is no reason why they can't replace fossil fuels.

Stop whining and DO SOMETHING!

Re:How much for how much?

[Anonymous Coward]

When the wind doesn't blow, the power is supplied by the same standard power plants that have been running all this time. When the wind blows, those standard power plants can decrease their output. At least that's what they do in countries like Spain. In some cases, energy from the wind is stored in uphill reservoirs at night and used when demand is high. New batteries, hydrogen from electrolysis and other energy storage means are being developed.

Re:How much for how much?

[Chrisq]

If we're going to add up these costs for coal then we need consider the incidental costs for wind as well. First thing that comes to mind is the 5MW natural gas turbines needed for when the wind does not blow.

This won't be a problem in practice until/unless wind power reaches around 10% of generation capacity. I hope it will be an issue eventually, but it is far from it at the moment

Re:How much for how much?

[Chrisq]

This won't be a problem in practice until/unless wind power reaches around 10% of generation capacity. I hope it will be an issue eventually, but it is far from it at the moment

At that point (>10%) the wind power generators should be spread over a very large area, reducing the probability that the entire installed base of generators will generate a low output at the same time. There are also other things to consider such as the likelihood that calm days will be sunnier days (not always, but often) therefore somewhat increasing the output from solar power. Combined with a smart grid and other sources of electricity such as nuclear and gas and tidal power there you have a recipe for a coal-free future.

There is also the ability to use pumped/stored hydropower combined with wind power to respond to peak demand or a short time when all other sources of at a low.

True, I have seen analysis that shows that continent sized grids can guarantee supply. The other thing that I think could be explored is variable pricing to large industrial consumers, though this should be put in place as a "green energy discount" - i.e. cheaper than now at times when there is an excess amount. Some industries can time their consumption to take advantage of lower price. I know that in the UK water companies pump water into towers and high-level reservoirs at night when electric demand is low, some of these operations they could delay if there was a daily price variation.

Re:How much for how much?

[Medievalist]

Has nobody invented a way to handle this other than shutting down the farm?

Why yes they have!

There's about half a dozen different techniques, and while there's definitely still room for innovation the problem is effectively solved for large off-shore wind turbines.

But the anti-wind nutbags like to ignore facts that don't fit their narrative - in the anti-wind world, there is no such thing as energy storage (cue shrill cries of "the wind doesn't always blow") and there is no way to deal with too much wind. You can't reason with them.

Not so fast

[icebike]

Its now a race to see who can get the first turbine up and spinning before anyone can claim to be first.

After years of opposition by Ted Kennedy, the Cape Cod wind farm was granted approval and all the law suits have pretty much played out.
The Cape Wind Farm gained final construction approval about this time last year (April 2011). Held up by yet another appeal due VFR (small plane) flights flying below regulation minimum altitude, it is expected to pass this hurdle as well, just like every other wind farm has. The opposition group has recently been fined for election violations.

But Approval does not mean construction has started, and both of these projects seem to be at the same point in their development.

Re:Too expensive

[icebike]

Twenty years is a long time. And after 20 years, you pull the turbine at the top of the towers and replace it with a new one, and slap the blades back on. The new one will be more efficient, cost less, and probably weigh less too, due to technology improvements over time.

The hard part is getting it permitted and construction started.
Keeping them maintained after the fact is just routine.

Re:Too expensive

[c0lo]

If a $2.1 million bond is required in case they need to remove the structure. The article says nothing about how much it will cost and if this investment will pay off in the long run. I doubt it especially since the turbine only has an expected life of 20 years.

In my understanding, it will cost nothing the taxpayer. TFA quotes:

Gamesa Energy USA, which is partnering with Huntingon Ingalls Newport News Shipbuilding, to develop and test new offshore wind technologies that will reduce the cost of wind power

The purpose of the project is to advance the demonstration of Gamesa Energy USA, LLC's new offshore WTG technology, the G11X, specifically designed for deployment in offshore wind environments worldwide.

Not only that it will cost nothing the taxpayer, but Gamesa pays an one-time royalty for the piece of ocean's bottom it uses and set aside the bond for removing the installation if/when decommissioned. Even more:

Although the project is just one single wind turbine generator and is not principally intended as major energy supply source, an added benefit of the prototype will be the production of up to five megawatts of clean, renewable wind power to the local Virginia transmission grid for public use.

In other words, making Virginia (and it's governor) look better, while being paid for it.

Can we stop whining now?

Re:Too expensive

[Qzukk]

If a $2.1 million bond is required in case they need to remove the structure.

Yeah, clearly they should just work like every other industry in America and when they close up shop, dump it on the taxpayers as a Superfund site.

Re:Too expensive

[JazzHarper]

To be a bit more specific, the bond is posted to make sure that the cost of removing the structure is covered, even if the company goes out of business. At today's interest rates, that should not be a terrible burden on the company. (They probably issued bonds to cover the bond).

Based on what is described in the article, this is how it should be done, IMO. No subsidies or tax gimmicks. The company, not the taxpayer, bears the economic risk. I tend to be skeptical of the viability of a lot of these alternative energy projects, but if they can make this work profitably, or even come close to breaking even while advancing the state of the art, it's a win for everyone. More power to 'em.

Do I understand ?

[BlueTak]

Reading the article, I understand that there is, just now, no offshore wind turbine near the coast of the US. It's so incredible for us Europeans, who have thousands of them for some years now that I think I have missed something....

Re:Do I understand ?

[khallow]

Yes, there are two reasons. First, the US doesn't subsidize wind like the European countries do. Second, the US has vastly more land-based wind power. That's still filling up.

There may also be serious regulatory obstacles as well. For example, the entire California coastline is a national monument. That's 1350 km roughly of 20,000 km of US coastline (including some of the largest population centers in the US). Similarly, Hawaii has 1200 km of coastline which is public property. There are smaller areas with similar laws such as the Outer Banks of North Carolina (a 110 km part is a national seashore).

A lot of coast just isn't near populated areas too. Alaska has almost 11,000 km of coastline, only a little of which is near any area with even modest population.

Re:Too expensive

[khallow]

Yeah, clearly they should just work like every other industry in America and when they close up shop, dump it on the taxpayers as a Superfund site.

While it might be different now, it's worth remembering that the Superfund program was remarkably shoddy, bureaucratic and should have been unconstitutional as an ex post facto law (it's status as civilian rather than criminal law seems more a dodge to get around that). So naturally, it was more reasonable for companies which had engaged in lawful activities to go bankrupt than deal with many years of Superfund legal nonsense and vast liabilities.

And given that the taxpayers voted for the people who created the Superfund program and wanted the sites cleaned, it makes sense for taxpayers to foot the bill.

where are you ppl when wars start?

[decora]

you dont want to build anything even remotely wasteful in regards to solar or wind, but by god lets throw a trillion dollars down the toilet to invade iraq and afghanistan for ten fucking years and accomplish some goal that nobody ever defined clearly.

Re:where are you ppl when wars start?

[coinreturn]

Mod +200 - No fucking shit.

Re:can someone explain

[Jeremi]

why wind is ever considered over solar? I mean, if the Sun dies, so do we, whereas if the wind stop blowing... no power.

As far as a solar power plant is concerned, the sun 'dies' every evening, and stays 'dead' until sunrise the next day.

Re:can someone explain

[jaymemaurice]

If only a windmill could point itself into into the wind with aerodynamics or something... and have large sweeping blades...

I'd bet more than 33%

[stomv]

NREL's ewits study modeled wind speed every 10 minutes at 1000s of sites both on- and -off-shore on the Eastern Interconnect, excluding the Southeast, at 80m and 100m hub height. They included a number of sites in VA and NC, both on and off-shore. I just happen to be working on a study now involving the data.

I chose 20 of their VA and NC offshore samples by sorting them by lat long and choosing every nth. I then ran the wind speed data of each sample through the power curve of a Vestas V112 3MW turbine [5MW turbines weren't appropriate for the study]. I then calculated the capacity factor at 100m hub height for all 8760*6*20 samples, and averaged. Capacity factor: 55.1%. Which is to say, the energy generated over the course of the year for a single 3 MW turbine at 100m hub height, expressed in MWh, will be 0.551 * 3MW * 8760. Of course, this is a model, not a prediction. The power density curve for a 5 MW turbine isn't exactly that of a 3 MW turbine, it may have maintenance issues, it may shut down during tropical storms and hurricanes, it may be in a site which is below the 20 site average, it may not be exactly 100m hub height (though 479 feet to tip of blade at max height seems close), it may and the NREL model which created the wind speeds may not be spot on either. I wouldn't bet the farm it hits 55.1% capacity factor, but I'd bet that it does significantly better than 33%.

This isn't to pick on the parent of this post, but more generally... like everything, the details matter. Like all things non-CS/CE, the /. collective is smart and educated enough to understand the conclusions, but not experienced enough in the specific area to produce quality conclusions. /rant

P.S. There isn't a "norm" for most wind... capacity factors on-shore in tUSA range from low 20s to almost 50. The capacity factor is only one input to determine the cost effectiveness of an installation. Other really important factors include the specific hours in the day that wind is expected to generating electricity, the challenge of installing turbines *at that specific location* [roads, foundation, transmission, etc], the requirements for permitting in that city/town and state (and sometimes Fed permitting too), the locational marginal price of electricity [if in ISONE, NYISO, PJM, ERCOT, CAISO, or to a lesser extent, MISO (ie New England, New York, North Atlantic ranging to Chicago, Texas, California, or the rest of the Midwest, roughly)] in the region, the value of capacity payments, the value of RECs or other environmental payments, and I'm sure I've left a few out.

Delaware

[shoehornjob]

Delaware is the first state (that I'm aware of) to propose off shore wind farms. Of course between the politicians and the special interests we managed to F#$ck it up. It's really a shame because (since I've lived here 10yrs) certain parts of the state have always had energy delivery problems and this project would have done a lot of good. Hopefully Virginia will have more luck with their offshore wind project.